欢迎访问济南科尔超声波设备有限公司网站!

专注生产工业用清洗设备

让工业清洗无难事

电话

业务咨询电话:

18663767799

你所在位置: 首页-新闻动态-新闻资讯-低温废水回收设备的操作注意事项
新闻资讯

低温废水回收设备的操作注意事项

作者:guanli来源:http://www.jnthcsb.com/时间:2022-09-25

为了更好地使用低温废水回收设备,我们在使用设备时须更加注意正常运行。以下是低温废水回收设备的操作注意事项,小编为您解答。
In order to better use the low-temperature wastewater recovery equipment, we must pay more attention to normal operation when using the equipment. The following are the precautions for the operation of the low-temperature wastewater recovery equipment, and I will answer them for you.
1、启动低温废水回收设备时检查电路、控制柜线路接线是否正确,电压和电流是否符合要求。
1. When starting the low-temperature wastewater recovery equipment, check whether the circuit and control cabinet wiring are correct, and whether the voltage and current meet the requirements.
2.低温废水回收设备的水泵采用防堵塞撕裂潜水排污泵。两个水泵的控制由微型计算机通过检测污水箱中的液位来完成。当液位从低到高达到工作水位时,启动工作泵。如果液位继续上升到警告水位,关闭工作泵,启动风机时检查旋转方向是否正确,避免反转。
2. The water pump of the low-temperature wastewater recovery equipment is a plug and tear resistant submersible sewage pump. The control of the two pumps is completed by the microcomputer through detecting the liquid level in the sewage tank. When the liquid level reaches the working water level from low to high, start the working pump. If the liquid level continues to rise to the warning water level, turn off the working pump, and check whether the rotation direction is correct when starting the fan to avoid reverse rotation.
3.当调节箱内污水较少,且液位低于水泵启动液位时,两台水泵将停止工作。此时,为使低温废水回收设备中的生物膜正常生长,风机将间歇启动10分钟,自动停止运行半小时。
3. When there is less sewage in the regulating tank and the liquid level is lower than the starting liquid level of the water pump, the two water pumps will stop working. At this time, in order to make the biofilm in the low-temperature wastewater recovery equipment grow normally, the fan will start intermittently for 10 minutes and automatically stop running for half an hour.
低温废水回收设备
4.沉淀池排泥控制。电磁阀通过空气提升污泥或污泥泵提升污泥。排泥周期为8小时,排泥时间为8分钟。当空气被提升时,两个风扇同时启动,以确保空气供应。
4. Sludge discharge control of sedimentation tank. The solenoid valve lifts the sludge through air or sludge pump. The sludge discharge cycle is 8 hours, and the sludge discharge time is 8 minutes. When the air is lifted, both fans are started at the same time to ensure the air supply.
5.风机和水泵由自动交替运行控制,交替切换时间为4小时。
5. The fan and water pump are controlled by automatic alternate operation, and the alternate switching time is 4 hours.
6、低温废水回收设备控制中心微机柜上按设计安排的工作程序一次完成。手动控制是通过面板上的按键开关,手动控制潜水排污泵和风机的开关。
6. The micro cabinet of the control center of the low-temperature wastewater recovery equipment shall be completed at one time according to the designed working procedure. Manual control is to manually control the switch of submersible sewage pump and fan through the key switch on the panel.
低温废水回收设备的操作注意事项相关内容便是如此了,如果您对此有什么不了解的地方,欢迎来我们网站www.jnthcsb.com咨询。
This is the case for the operation of low-temperature wastewater recovery equipment. If you have any questions about this, please visit our website at www.jnthcsb.com.